FrostyTech.com Heatsink Reviews and Analysis
      
TOP 5 Heat Sinks     TOP 5 Low Profile Heat Sinks     TOP 5 Liquid Coolers    
 Reviews + Articless     News     HSF Mfg's Index     Advanced Search    

Cooler Master Aero1 ASB-V73-U1 Copper Heatsink
Cooler Master Aero1 ASB-V73-U1 Copper Heatsink
  87%   
Abstract: Squirrel cage fans have a couple of benefits over standard vaneaxial fans when it comes to lower-noise heatsinks, though they don't tend to deliver nearly as much air.

 Company link  Category  Published  Author 
Coolermaster   Cooling / Heatsinks   Jun 30, 2003   Max Page  


Cooler Master Aero1 ASB-V73-U1 Copper Heatsink Review

Remember the German-born Noisecontrol Silverado heatsink that came out a few years back? Well the Coolermaster Aero ASB-V73-U1 uses a similar configuration, with a few distinctive differences of course. Where the Silverado used a rather lack-luster extruded aluminum heatsink - albeit coupled with a pure silver disk - the Coolermaster Aero1 uses a full copper skived body. The Silverado also used two squirrel cage fans for air delivery because of their lower noise output. Coolermaster use a relatively loud squirrel cage fan on the Aero1, though it is a custom unit that exhausts air over an area of about 50x55mm.

Squirrel cage fans have a couple of benefits over standard vaneaxial fans when it comes to lower-noise heatsinks, though they don't tend to deliver nearly as much air. One of the prime reasons these types of fans can make a good air delivery source for a heatsink is that their exhaust is uniform - in other words there are no dead spots. A vaneaxial fan on the other hand will tend to have a dead spot right below the motor. Since most fans sit squarely up on the heatsink itself this puts the dead spot directly above the hottest section of the heatsink.

When Frostytech first started out three years ago we did some testing with squirrel cage fans and if I remember accurately the type we tested with were good, but not necessarily 'better' due to the typically lower CFM rating. At the time we discovered a better solution to vaneaxial fan dead spots in the form of Angled Fan Orientation (AFO) and went with that. AFO is beyond the scope of this review, however you can see an example of it in the FrostyTech GF4TEC project if you're interested in the technique.

The Coolermaster ASB-V73-U1 Aero1 comes with a small potentiometer that is hardwired directly into the squirrel cage fan. The potentiometer enables the user to manually adjust fan speed between 1900RPM-4500RPM with the turn of a dial. The upside to this configuration is that user can tune the computer to be as noisy or quiet as desired. The downside is that this is not a dynamic adjustment - meaning that if the computer is put under load and the processor thermals rise up, the heatsink won't automatically compensate and kick up the fan's RPM.

Heatsink Specsheet:
  • Model: ASB-V73-U1
  • HS Material: skived copper, aluminum
  • Fan: 19000-4500 RPM,12V, 1.2A
  • Fan Dim: 70x70x70mm
  • FHS Dimensions: 107x72x71mm
  • Made by: Coolermaster
Sold By: www.coolermaster.com
Heatsink Audio Sample Included.

Because the fan draws as much as 1.2A of current, the fan get its power from a standard molex pass through connector. A separate three-pin jack plugs into the motherboard to deliver the single RPM signal.

With the Coolermaster ASB-V73-U1 Aero1 heatsink comes a 3.5" aluminum bay cover and standard steel expansion slot PCI bracket. The fan-speed potentiometer can be bolted to either of these face plates (lead wires are 19" long) with the intent of allowing the user to control fan speed without having to crack open the case and poke around inside.

If you have an aluminum case, you'll be pleased to see that the 3.5" aluminum bracket is tastefully done, and should in nicely. By mounting the dial on the PCI bracket you can put it in a less obvious location at the rear of the PC. However, since the potentiometer is not removable from the heatsink it has to go in either one of these locations. The component itself is primarily metal, so leaving it dangling around in the case could be a quick route to shorting out the videocard or motherboard.

The Aero1 fan is an interesting fan as far as computer cooling goes. There hasn't been many other AthlonXP heatsinks, if any, that make use of a fan like this. Nvidia's GeforceFX 5800 Ultra has had the pleasure of being equipped with a monster squirrel cage fan, so I'm kind of left wondering if this is an offshoot of that application.

Anyway, it will be interesting to see if Coolermaster begin selling this fan by itself in the near future. Now let's take a closer look at the Aero1 and see what really makes it tick!


° Next Page 

Table of Contents:

 1: — Cooler Master Aero1 ASB-V73-U1 Copper Heatsink
 2:  The heatsink from all sides
 3:  Heatsink Thermal/Acoustic Test Parameters
 4:  Thermal And Acoustic Results
 5:  Final Temperature Results

List all Coolermaster heat sinks that Frostytech tested?

Follow Frostytech on FacebookFrostytech News RSS FeedFollow frostytech on Twitter
Resources
° Got Feedback?
° Mk.II Test Platform
° Where To Buy?
° Manufacturer Index
° Industry Dir.
° Cooling Projects

Scythe Ninja 4 SCNH-4000 Heatsink Review

DeepCool Maelstrom 240 Liquid Cooling System Review

DeepCool Gamer Storm Lucifer K2 Heatsink Review

Gelid Antarctica Heatsink Review

Noctua NH-D9L 3U Low Noise Heatsink Review

BeQuiet Shadow Rock LP Heatsink Review
...More Articles >>




Websites you may also like:
PCSTATS

Google Search Frostytech

Time stamped: 8:45PM, 11.24.2017
In Case You Missed it...
°  Reeven & ThinkComputers Holiday Giveaway

°  Scythe's Mugen 5 Rev. B

°  Noctua NH-L12S Low-Profile cooler

°  Corsair's ML120 Pro RGB fans pair

°  Scythe Mugen 5 Rev B SCMG-5100 Heatsink Review

°  Samsung to continue adopting heat pipes for smartphones in 2018




FrostyTech.com
Since June 1999


Find a Heatsink / RSS Feeds
Latest Heatsink Reviews
Top 5 Heatsinks Tested
News RSS Feed
Reviews RSS Feed


Social Media
Facebook
Twitter
Pinterest


FrostyTech.com Info
Feedback
Contact Us / Heatsink Submissions
Submit News
Legal
Suite 66
© Copyright 1999-2017 www.frostytech.com All Rights Reserved. Privacy policy and Terms of Use
Images © FrostyTech.com and may not be reproduced without express written permission.
Current students and faculty of accredited Universities may use Frostytech images in research papers and thesis, provided each image is attributed.